Product ID:Q4-2817 FLUOROSILICONE SEALANT
MSDS Date:05/25/1994
FSC:8030
NIIN:00-755-4760
Status Code:A
MSDS Number: CKMPH

ROBERT MCKEOWN CO.

111 CHAMBERS BROOK RD.
BRANCHBURG, NJ 08876
US

Emergency Phone: (800)424-9300

Info Phone: 908-218-9000

Cage: 7B953

MCKEOWN ROBERT CO. INC.

SOMERVILLE, NJ 08876 US

Telephone: 908-218-9000

Cage: 7B953

IRON OXIDE

CAS: 1332-37-2

RTECS: NO7380000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

METHYLTRIACETOXYSILANE

CAS: 4253-34-3

RTECS: VV4500000

ETHYLTRIACETOXYSILANE

CAS: 17689-77-9

TRIMETHYLATED SILICA

CAS: 68909-20-6

Health Hazards Acute and Chronic:EYE: DIRECT CONTACT IRRITATES
MODERATELY WITH REDNESS AND SWELLING. SKIN: A SINGLE SHORT EXPOSURE
( LESS THAN 24 HOURS) MAY IRRITATE. REPEATED OR PROLONGED CONTACT
( 24 TO 48 HOURS) MAY IRRITATE MODE RATELY. INHALATION: VAPOR
EXPOSURES MAY IRRITATE EYES, NOSE AND THROAT. ORAL: SMALL AMOUNTS
TRANSFERRED TO MOUTH BY FINGERS DURING USE ETC. SHOULD NOT INJURE.
SWALLOWING LARGE AMMOUNTS MAY INJURE SLIG HTLY.

First Aid:EYE: IMMEDIATELY FLUSH WITH WATER FOR 15 MINITUES. GET
MEDICAL ATTENTION. SKIN: REMOVE FROM SKIN AND WASH THROUGHLY WITH
SOAP AND WATER OR WATERLESS CLEANSER. GET MEDICAL ATTENTION IF
IRRITATION OR OT HER ILL EFFECTS DEVELOP OR PERSIST. INHALATION:
REMOVE TO FRESH AIR. ORAL: GET MEDICAL ATTENTION.

Flash Point Method:CC
Flash Point:>101.1C, 214.F
Extinguishing Media:CARBON DIOXIDE (CO2), WATER, WATER FOG (OR SPRAY),
SRY CHEMICAL, FOAM
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING SHOULD BE WORN IN FIGHTING FIRES INVOLVING
CHEMICALS. EVACUATE AREA IN CASE OF OVERHEATING OR FIRE.
Unusual Fire/Explosion Hazard:MAY FORM HIGHLY TOXIC VAPORS OF
TRIFLUOROPROPIONALDEHYDE IF HEATED IN AIR ABOVE 300F.WHEN HEATED TO
TEMP. ABOVE 180 IN THE PRESENCE OF AIR PRODUCT CAN FORM
FORMALDALHYDE VAPORS WICH ARE KNOWN POTENTI AL CANCER HAZARDS AND A
KNOWN SKIN AND RESPRITORY SENSITIZER AND IRRITANT TO
EYES/NOSE/THROAT/SKIN/DIGESTIVE SYSTEM.

Spill Release Procedures:SCRAPE UP AND CONTAIN FOR SALVAGE OR DISPOSAL.
OBSERVE ALL PERSONAL PROTECTION EQUIPMENT RECOMMENDATIONS.

Handling and Storage Precautions:KEEP CONTAINER CLOSED AND STORE
AWAYFROM WATER OR MOISTURE.

Respiratory Protection:USE ORGANIC VAPOR TYPE RESPIRATOR IF ADEQUATE
VENTILATION IS NOT PROVIDED.
Ventilation:LOCAL EXHAUST AND GENERAL VENTILATION RECOMMENDED
Protective Gloves:CHEMICAL PROTECTIVE GLOVES AS A MINIMUM
Eye Protection:USE SAFTEY GLASSES AS A MINIMUM
Work Hygienic Practices:WASH AT MEALTIME AND AT END OF SHIFT.
CONTAMINATED CLOTHING AND SHOES SHOULD BE REMOVED AS SOON AS
PRATICAL AND THROUGHLY CLEANED BEFORE REUSE.
Supplemental Safety and Health
ACIDIC ACID IS FORMED UPON CONTACT WITH WATER OR HUMID AIR. PROVIDE
ADEQUATE VENTILATION TO CONTROL EXPOSURES WITHIN GUIDELINES.

Spec Gravity:1.80
Solubility in Water:NONE
Appearance and Odor:RED PASTE ACETIC ACID ODOR

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION
Hazardous Decomposition Products:THERMAL BREAKDOWN DURING FIRE OR VERY
HIGH HEAT CONDITIONS MAY EVOLVE THE FOLLOWING PRODUCTS: FLUORINE
COMPOUNDS, CARBON OXIDES, INCOMPLETELY BURNED CARBON COMPOUNDS,
SILICON DIOXIDE, FORMALDEHYDE.

Waste Disposal Methods:DISPOSAL OF COLLECTED PRODUCT, RESIDUES AND
CLEAN-UP MATTERIALS MAY BE GOVERNMENTALLY REGULATED. OBSERVE ALL
APPLICIAPLE LOCAL, STATE AND FEDERAL WASTE MANAGEMENT REGULATIONS.
LOCAL, STATE AND FEDERAL REPORTING REQUIRMENTS MAY APPLY TO SPILLS
OR RELEASE OF THIS MATERIAL INTO THE ENVIORMENT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

SARA Title III Information:SECTION 312: ACUTE-YES
State Regulatory Information:NEW JERSEY: TRIFLUOROPROPYLMETHYL
SILOXANE, HYDROXY-TERMINATED, IRON OXIDE, TRIMETHYLATED SILICA,
ETHYLTRIACETOXYSILANE, METHYLTRIACETOXYSILANE. PENNSYLVANIA:
TRIFLUOROPROPYLMETHYL SILOXANE, HYDROXY-T ERMINATED, IRON OXIDE,
TRIMETHYLATED SILICA, ETHYLTRIACETOXYSILANE.